Transcript MANUAL SHINGA GRANNY

Life is like riding a bicycle – in order to keep your balance, you must keep moving
MANUAL
SHINGA GRANNY
(VERSION MIDMOTOR)
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
1
Life is like riding a bicycle – in order to keep your balance, you must keep moving
SAFETY AND SHINGA
SAFETY COMES ALWAYS FIRST. READ THE FOLLOWING SAFETY ADVICES THOROUGLY REGARDING OUR (ELECTRICAL) BIKES:
1. SHINGA E-BIKES ARE EQUIPPED WITH AN ELECTRIC MOTOR. IT IS OF GREAT CONCERN TO LEARN HOW TO USE THE E-BIKE
PROPERLY AND DRIVE IN COMPLIANCE WITH THE LOCAL TRAFFIC REGULATIONS. WE ADVICE FIRST TO DO SOME PRACTICE
RUNS ON EASY ROADS AND LESS TRAFFIC TO GET FAMILIAR WITH THE E-BIKE.
2. DON’T STAND ON THE PEDALS WHEN YOU START RIDING THE BIKE. SIT FIRST ON THE SADDLE AND START PEDALLING.
3. RIDE PREFERABLY THE FIRST FEW DRIVES WITHOUT THE ELECTRIC MOTOR TO GET FAMILIAR WITH THE E-BIKE. START
GRADUALLY WITH LOW POWER SETTING AND INCREASE ONCE YOU ARE FAMILIAR WITH THE E-BIKE.
4. THE SHINGA E-BIKES ARE TESTED BY US. TESTS TAKES APPROXIMATELY 15MIN ACCORDING OUR PROTOCOL. HOWEVER, IF
IN ANY DOUBT REGARDING THE BIKE AND THE ELECTRONIC INSTALLATION, CONTACT US IMMEDIATELY.
5. DO NOT EXPOSE BATTERY AND CHARGER IN DIRECT SUN. BATTERY IS PROTECTED AGAINST HEAT, BUT OVERHEATING MUST
BE AVOIDED AT ALL TIMES.
6. ONLY USE THE ORIGINAL CHARGER SUPPLIED WITH THE E-BIKE TO AVOID DAMAGE TO THE BATTERY AND THE ELECTRONIC
INSTALLATION.
7. BRAKES ARE PROVIDED WITH “ABS” SAFETY. WHEN YOU BRAKE (AND STOP PEDALLING), THE ELECTRIC MOTOR WILL STOP.
8. WE ADVICE TO USE A HELMET WHEN RIDING THE BIKE.
SHINGA E-BIKES ARE MANUFACTURED ACCORDING EUROPEAN GUIDELINES AND REGULATIONS. FOR QUESTIONS AND/OR
REMARKS, YOU CAN CONTACT US ON THE BELOW MENTIONED CONTACT INFORMATION.
WE ARE ALWAYS AVAILABLE FOR OUR CUSTOMERS:
E-MAIL: [email protected]
TELEPHONE: +31 85 401 2738
WITH KIND REGARDS,
Ton van den Oetelaar
CEO SHINGA BV
* Shinga follows guidelines: EN 14764 + for electronic parts EN 15194, see page 11
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
2
Life is like riding a bicycle – in order to keep your balance, you must keep moving
CONTENT
Introduction: .......................................................................................... 4
Safety tips: ............................................................................................. 4
! Safety regulations !: ............................................................................. 5
Important notice: ................................................................................... 5
Manual SHINGA GRANNY: ...................................................................... 6
Pre-ride checks: ...................................................................................... 6
Easy start up: .......................................................................................... 7
Charging/removing battery: ................................................................... 8
General information about the E-bike: .................................................... 9
Technical specifications: ....................................................................... 10
Location of framenumber: .................................................................... 10
Contact information Shinga BV: ............................................................ 10
EU Declaration of Conformity: .............................................................. 11
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
3
Life is like riding a bicycle – in order to keep your balance, you must keep moving
Introduction
Thank you for choosing Shinga. This manual is written for convenient use and to safeguard the use of the E-Bike. After reading this
manual you can get familiar about the functions and proper use of our E-bikes. The technical design of the E-Bikes are reliable, we
use quality parts and together with our high standard of service, we can provide you with an E-bike which is easy to use, reliable,
all together with a high range. Therefore an ideal transport for all our customers around the globe. Your opinion is highly
appreciated to improve our products and to create a perfect bike with the latest technology
We strive to produce an E-bike that meets the requirements and needs of our customers.
Safety tips
1.
2.
3.
4.
5.
6.
7.
8.
Check on a regular basis for external damage before you use the E-Bike.
Drivers can reduce the possibility of accidents by:
a. Wearing light clothes;
b. Use of (head)lights;
c. Keep distance with other vehicles;
d. Comply to local traffic regulations;
e. Reach hand out to the direction before you turn;
f. Never use one hand for a longer time to steer. Use both hands;
g. Never ride the bike with 2 or more persons (exception for one small child on the backseat);
h. Do not brake extreme during rain or wet road.
Caution with loose clothes.
Caution when wearing long overcoat, long dresses during step up/out and drive.
Carrying goods/bagage;
a. Do not exceed payload more than 25 Kgs or a total weight of 140 Kgs with the E-Bike, driver weight and goods;
b. Secure goods/baggage before you ride;
c. Preferably no baggage on the steer to avoid swaying of the E-Bike.
Do not use Pressure washer to avoid electrical damage.
Maximum of 10 Kgs static load of the steer. Do not use child seat up front.
Baggage carrier is only to be used for baggage.
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
4
Life is like riding a bicycle – in order to keep your balance, you must keep moving
! Safety regulations !
1. To ensure safe driving, it is important to read the instructions. For any discrepancy in our manual, contact us.
2. Comply to local traffic regulations , do not ride with 2 or more persons, reduce speed during bad weather, wet road or
down/uphill.
3. The E-bike can be used during rain and snow, but it must not be immersed in water to prevent damage to the motor,
battery and electrical parts.
4. Reparation must only be done by Shinga or its approved agent with parts approved by Shinga.
5. Never lend the E-Bike to persons not familiar with E-bikes to prevent accident and injury.
6. Do not drink and drive. Stay focus while riding.
7. Maximum payload is 140 kgs.
8. Exceeding payload may decrease safety and increase damage to the E-Bike.
9. Do not modify the E-bike yourself. This will void the warranty.
10. The maximum speed is set to 25Km/h. It is not permitted to increase the maximum speed. If changes are made in the
settings, the driver will be liable for any accidents occurred.
11. When the front fork or steer is damage after an accident, it must be replaced to insure the bike’s integrity.
Important notice:
According to the Dutch regulations an electric bicycle must be equipped with the following:







Two independent functioning brakes
Head light
Rear light
Spoke reflector, reflective tires or rimes
Pedals with reflectors
Front reflector (if not build in head light)
Rear reflector
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
5
Life is like riding a bicycle – in order to keep your balance, you must keep moving
Manual SHINGA GRANNY
The electric bike SCAMPER is available in different configurations.This manual apply tot the SHINGA GRANNY equipped with a
midmotor.
Pre-ride checks:
Check on a regular basis the following components:








Brakes
Spokes
Lights
Bike bell
Tire tensions (minimum 3.5 bar, maximum 5.0 bar)
Tire profile
Securing the battery
Electrical system operations
Electrical support/ Sensitivity:
The GRANNY with the midmotor has a control panel on the left side of the steer [+ and -]. You can adjust the sensitivity of the
power support, ranging between 1 to 5. Number 1 has the lowest power support, number 5 will give you the most power support.
Tip: If you are not familiar with the E-Bike, try using without power support. Increase power support when you are more
accustomed with the E-bike.
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
6
Life is like riding a bicycle – in order to keep your balance, you must keep moving
Easy start up:
1. Activate battery by pressing the On/Off switch.
2. Turn controller on by pressing the “Power” button for a few seconds.
3. To activate front and rear light, press “+” for 2 seconds. A
symbol will
appear on the display unit. To turn off press same button for 2 seconds.
5. Electrical power support
To increase electrical assistance, short press “+” for each instance.
To decrease electrical assistance, short press “-“ for each instance.
See previous page for more details.
6. By using the gear handle, you can change the gear setting and
increase/decrease speed. Towards you to change to a higher gear, away
from you to change to a lower gear. Gear display show current gear setting.
7. Brakes
By gently squeezing the brake levers during riding, the bike will slow down
speed and will interrupt the active motor. Caution when you release the
brake levers, the motor will restart when the bike is not fully stopped.
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
7
Life is like riding a bicycle – in order to keep your balance, you must keep moving
Charging/removing battery:
Warning:
 Avoid damage from short circuit between the positive and negative poles of the charger and battery.
 Do not open charger to avoid damage and injury.
 Keep in mind that the charger can be warm during charging. Place the charger on a surface that can withstand
heat.
 Do not cover the charger so it can cool down. Do not place inflammable or explosive goods in the vicinity of the
charger to prevent danger.
 Store the charger and battery on a safe place out of reach from children.
 Do not expose the charger and battery in direct sunlight. Store the battery and charger on a cool place.
1. The supplied charger operates with 110/230V.
The switch-plug can be connected to the power socket.
A connection point is located at the left side of the
battery. Red light indicate charging. Green light indicate
fully charged.
13,5AH: Aprox. 6/7 hour charging time
TIP:
 First connect the charger with the bike before connecting to the power socket.
 Batteries are made of Lithium, they can be recharged after every use.
 The charger stop charging when the battery is fully charged. You can disconnect the charger.
 Keep the battery dry and frost-free.
 When you are not planning to use the battery for a longer period, store the battery separate from the E-Bike
fully charged.
 It is advisable to fully deplete the battery the first 3 times and after every 100 charge cycles and do a full
charge.
 The distance (maximum range) of one battery depends on weather/road conditions, weight of the driver, tire
tension, power setting, frequent braking/accelerating and battery condition.
 The battery charge according a curve. The first few hours it will charge the most energy. Above 90% it will
charge significant slower.
2. The battery can be removed by turning the key on
the left side of the battery to the left and pull the
battery out of the battery case.
Lock and secure the battery when you place it back.
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
8
Life is like riding a bicycle – in order to keep your balance, you must keep moving
General information about the E-Bike:
1. The E-Bike is mechanically the same as a normal bike. All moving parts, like cables, brakes, gear and axes can be
maintained by using silicon or telfonspray.
Check on a regular basis if all bolts and screws are secured. Important points are front and back wheel, luggage rack
and steering.
Tip:
Spray chain and gear after a wet parcours, the chain needs the most lubrication.
You can clean the chain with a cleaning kit, available at any bike shop.
Tire size is 28 inch, available at any bike shop.
Caution with moist, store the bike in a dry environment. Sensitive parts are the display unit and the
controller.
Rusting parts can be treated with telfonspray.
Keep the bike clean and dry to limit corrosion.
2. Gear
You can consult a bike technician for gear adjustments.
Many information about Shimano NEXUS gears is
available on the internet.
3. Tire pressure.
Keep the tires on tension. This improves driving
experience and range. We advice a pressure of 4 bar.
4. Brakes
Brakes may need to be adjusted after a while. This can
easily be done on the brake levers on the steering or the
brake mechanism on the wheels. For safety reasons,
consult a bike technician for gear and brakes adjustments.
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
9
Life is like riding a bicycle – in order to keep your balance, you must keep moving
Technical specifications:
1. Frame: aluminium
2. Motor type: without brushes, midmotor
3. Motor voltage: 36 V
4. Motor output: 250 W max
5. Battery type: lithium polymeer battery
6. Battery specifications: 36 V, 13,5AH from Samsung
7. Accu lader: 110..240V/AC 1.5A > 36V/DC 2A
8. Electric power support: 5 settings
9. Gears:3 or 7 (option)
10. Range: 50 to 80 Km
11. Maximum payload: 140 Kgs
12. Netto weight: 28 Kgs
13. Wheel diameter: 28 inch
14. Maximum speed: up to 25 km/h (electric supported)
Frame number is located near the pedle axel.
(Maybe needed for insurance)
Contact information Shinga BV
SHINGA BV | Molendijk Zuid 23b | 5482WZ Schijndel | The Netherlands |
Email: [email protected] | KVK : 62140957
BTW: NL854680950B01
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
10
Life is like riding a bicycle – in order to keep your balance, you must keep moving
EU Declaration of Conformity concerning machines
Supplier:
Technical Documents:
Manufacturer:
SHINGA BV
MOLENDIJK ZUID 23B
5482 WZ SCHIJNDEL
VAN DEN OETELAAR (SHINGA BV)
HARRY JANSENLAAN 12
5481 CB SCHIJNDEL
ZHEJIANG JSL VEHICLE CO., LTD
B1.NO.609 SOUTH JINXING STREET
JINHUA, ZHEJIANG , CHINA
Product: electric bike
Model: JSL 036X
Name: Shinga Granny
Serialnumber bike:
……………………………………………………………………………………………………………………………….
Serialnumber motor: ……………………………………………………………………………………………………………………………
Serialnumber battery:
………………………………………………………………………………………………………………………….
THIS E-BIKE IS MANUFACTURED ACCORDING AND IN APPLIANCE WITH EUROPEAN UNION GUIDELINES AND REGULATIONS
CONCERNING ELECTRIC BIKES WITH A MAXIMUM SPEED OF 25 KM/HOUR AND A MAXIMUM MOTOR OUTPUT OF 250W
THE FOLLOWING “EN” (ISO) STANDARDS APPLY:
EN ISO 12100:2010 ; EN 15194:2009 ; EN 14764:2005 ; EN 349:1993+A1:2008 ; EN 953:1997+A1:2009 ; EN 13857:2008
EU GUIDELINES APPROVAL:
2006/42/EC MACHINERY DIRECTIVE ; 2006/95/EC LOW VOLTAGE DIRECTIVE ; 2004/108/EC ELECTROMAGNETIC COMPATIBILITY
DIRECTIVE
EU CERTIFICATION AGENCY: ENTE CERTIFICAZIONE MACHINE S.R.L., VIA MINCIO 386, 41056 SAVIGNANO, ITALIE ; NOTIFICATION
AGENCY EU-TYPE EXAMINATION NUMBER: 1282
CERTIFICATE NUMBER: 111123/ZJV845
CERTIFICATE DATE: NOVEMBER 2011
Shinga BV - Molendijk Zuid 23b - 5482WZ Schijndel – The Nederlands - Tel: +3185 401 2738 - eMail: [email protected] - KvK: 62140957
Manual Shinga Granny midmotor version July 2016.docx
11