Transcript drivers-jan-overview-v1.ppt

Jan M. Rabaey
EECS Dept.
Univ. of California, Berkeley
BWRC 2003 Winter Retreat
PicoRadio’s ─ The Mission
Ubiquitous Sensor and Monitor Networks
Meso-scale low-cost radio’s for ubiquitous wireless
data acquisition that
• are fully integrated
–Size smaller than 1 cm3
• minimize power/energy dissipation
– Limiting power dissipation to 100 mW
enables energy scavenging
• and form self-configuring ad-hoc networks
containing 100’s to 1000’s of nodes
BWRC 2003 Winter Retreat
Wireless Sensor Networks
• Dominant trend in Wireless Industry:
More Bits/sec/(Hz)
• Wireless sensor networks offer interesting alternative:
More bits/$/nJ
Smart buildings
Traffic
management
Energy
BWRC 2003 Winter Retreat
management
Medical
Infrastructure
maintenance
PicoRadio Team
•
Faculty
–
–
–
–
–
•
•
•
Fred Burghardt
Sue Mellers
Jonathan Reason
Hugo Shi
Reto Stutz
Yuen Hu Chee
Richard Lu
Brian Otis
Nathan Pletcher
Uli Schuster
Energy Scavening and
Packaging
–
–
–
Mike Montero
Dan Odell
Shad Roundy
BWRC 2003 Winter Retreat
•
Marco Sgroi
Rong Zhong
Networking, MAC and
Locationing
–
–
–
–
–
–
–
–
–
RF
–
–
–
–
–
Design Tools
–
–
Testbed
–
–
–
–
–
•
Jan Rabaey
Paul Wright
Kannan Ramchandran
Ali Niknejad
Alberto Sangiovanni-Vincentelli
•
Chunlong Guo
Tufan Karalar
Enyi Lin
Nir Matalon
Dragan Petrovic
Rahul Shah
Jana Van Greunen
Mei Xu
Charlie Zhong
Digital Network Processor
–
–
–
–
–
–
–
–
–
Josie Ammer
Mika Kuulusa
SuetFei Li
Jacob Poppe
Huifang Qin
Mike Sheets
Jonathan Tsao
Ruth Wang
Janie Zhou
PN-IIIv1: The First Self-Contained Sensor Node
Solar Cell
(0.5 mm)
Battery (3.6
mm)
PCB (1
mm)
Chip encapsulation
(1.5 mm)
Version 1: Light Powered
Size determined by power
dissipation (< 0.5 mW avg)
BWRC 2003 Winter Retreat
Components and battery
mounted on back
Version 2: Vibration
Powered
PN-IIIv1 Architecture: The “Quark” ChipSet
Digital
Network
Processor
(“Charm”)
16kB
CODE
Flash
Storage
4kB
XDATA
256
DATA
Chip
Supervisor
DW8051
20MHz
Clock Source
Serial
Powertrain
sfrbus or membus?
FlashIF
Solar Cell
SIF
ADC
MAC
Voltage
Voltage
Supply
Voltage
Supply
Supply
SIF
LocalHW
Serial
GPIO
ADC
PHY
Sensor1
Sensor2
PrgThresh0 PrgThresh1
User
Interface
Microresonators
(“Up and Down”)
BWRC 2003 Winter Retreat
OOK
Receiver
Tx0
Tx2
OOK
Transmitter
RF Transceiver
(“Strange”)
SIF = sensor interface
“SmorgasBoard”
Prototyping All Components of PNv3
Solar-cell based
energy scavenging
Vibration-based
energy scavenging
Dynamic Memory
Power-down Test
BWRC 2003 Winter Retreat
FBAR based radio
“Strange”: Back to The Future
(Courtesy of Brian Otis)
© 2000 - Direct Conversion
fc= 2GHz
>10000 active devices
no off-chip components
© 1949 - superregenerative
fc= 500MHz
2 active devices
high
quality
passives - hand tuning
BWRC
2003 off-chip
Winter Retreat
D. Yee, UCB
Back to The Future
OSC1
MOD1
OSC2
Preamp
Matching
Network
PA
MOD2
FBAR-based
RF Filter
RF Filter
Env
Det
RF Filter
Env
Det
A
Simplicity Rules
•
•
•
•
•
Minimizes use of active components
Uses simple modulation scheme (OOK)
Allows efficient non-linear PA
Down-conversion through non-linearity (Envelope Detector)
Tx and Rx in 3-4 mW range (when on)
BWRC 2003 Winter Retreat


fclock
fclock
The “Strange” Components
OSC/PA
LNA
Testchip in 0.13 mm CMOS
Fully functional
PA
Test
300mm
OSC
ENV
2mm
Inductors
Agilent FBAR
Technology
Co
BWRC 2003 Winter Retreat
Rx
C x Lx
An Operational PicoRadio (RF) !!!
Built by chaining prototype-chip
components using
chip-on-board assembly.
Implements complete TX and RX
functionality
FBAR
300m
m
2mm
BWRC 2003 Winter Retreat
An Operational PicoRadio (RF)
Built by chaining prototype-chip
components using
chip-on-board assembly.
Implements complete TX and RX
functionality
FBAR
Out
300m
m
2mm
RF
In
BWRC 2003 Winter Retreat
“Strange”─The Integrated Version
OSC1
MOD1
OSC2
PA Test
MOD2
4 mm
LNA
Test
TX1
Passive
Test
Structures
Receiver
OSC1
Diff
Osc
MOD1
OSC2
Preamp
Matching
Network
PA
MOD2
Env Det
Test
TX
TX
On:
On:44mW
mW
Stby:
Stby:11mW
mW
Off:
Off:00mW
mW
TX2
Preamp
PA
Matching
Network
TX
TX
On:
On:44mW
mW
Stby:
Stby:11mW
mW
Off:
Off:00mW
mW
• Technology: 0.13 mm CMOS
combined with off-chip FBARs
• Carrier frequency: 1.9 GHz
• 0 dBm OOK
• Two Channels
• Channel Spacing ~ 50MHz
• 10-160 kbps/channel
RF Amp Test
fclock
RF Filter
RF Filter
Env
Det
RF Filter
Env
Det

LNA
fclock

BWRC 2003 Winter Retreat
RX
RX
On:
On:33mW
mW
Off:
Off:00mW
mW
In fab as of December 10
Pro’s or Con’s of Simple Radio’s
• Small Change in Path Loss
Has Dramatic Impact on
Transmission Quality
0
10
20 kbps, +1.5dBm
40 kbps, +3dBm
80 kbps, +4.5dBm
-1
10
– Channel is either “good” or
“bad”
-2
10
• Reducing Symbol Time (or
Increasing Data Rate)
Reduces Energy/bit for
same QOS
-3
BER
10
-4
10
-5
10
– Factor 2 reduction in symbol
time for 1.5 db in path gain
-6
10
-7
10
-36
-35
-34
-33
effective path loss
-32
Simulated response of PN3v1 radio
BWRC 2003 Winter Retreat
-31
-30
• Go for fastest possible
radio that simple scheme
allows (limited by ISI)
Integrated NanoMechanical Filter Technology
(In cooperation with R. Howe and BSAC)
Sense
Electrode
Drive
Electrode
RBAR: Radial
Bulk Annular
Resonator
B. Bircumshaw and
A. Pisano
g
ri
Substrate
BWRC 2003 Winter Retreat
ro
Integrated NanoMechanical Filter Technology
Shear Ring Resonator (SRR)
Differential drive and differential
sense electrodes are alternated
along the circumference:
+ 24 dB in Dynamic Range
(S. Bhave and R. Howe)
–Drive
SiC versions of RBAR
and SRR in fab
+Drive
–Sense
BWRC 2003 Winter Retreat
+Sense
Reactive Digital Network Processor (“charm”)
Sensor/actuator
interface
App/UI
User
interface
Sensor/
actuators
Prototyped on FPGA
In Fab March 03
Aggregation/
forwarding
Transport
16kB
CODE
Network
Energy
train
Chip
Supervisor
DLL (MAC)
Locationing
Interconnect network
RF (TX/RX)
Antenna
• Reactive inter- and intra-chip signaling
• Aggressive Use of Power-Domains
• Chip Supervisor Manages Activity
BWRC 2003 Winter Retreat
Chip
Supervisor
DW8051
Serial
Baseband
Reactive
radio
256
DATA
4kB
XDATA
FlashIF
SIF
MAC
ADC
SIF
LocalHW
PHY
Serial
GPIO
ADC
1 mW on
< 10 mW sleep
Size: 6 mm2
Synchronization Block Diagram
Synch Algorithm:
1.
Carrier Detect
•
•
2.
Symbol and Packet Timing
Estimation
•
3.
Indicates carrier detected to DLL
layer
Sets threshold for timing estimation
Sets timing and threshold for bit
decisions
?
Carrier
Sense
Carrier Detected
Threshold
Est.
Symbol and Packet
Timing Estimation
Bit Decisions
Timing
Threshold
Bits
ADC
Envelope
Detector
Analog
Filter
ADC
Matched
Filter
Slicer
Estimated Complexity: 65 kGates
BWRC 2003 Winter Retreat
Locationing Engine ─
Floor plan and Dataflow
Maintenance (11K μm2 )
LS Back
Substitute
Flooding Block
(36K μm2)
(76K μm2)
LS CORDIC
(67K μm2)
Receive
Packet
(21K μm2)
LS Matrix Memory
(111K μm2)
LS Setup(23K μm2)
Least Squares (LS) Solver
Received
Packet
Transmit
Packet
(17K μm2)
Update
selfposition
Broadcast
to
neighbors
Update neighbor-list
Performs first-order locationing based on hop-count
BWRC 2003 Winter Retreat
Prototyping Protocol Processor on FPGA
Area Percentage Breakdown
13.0%
0.3% 6.7%
10.9%
0.1%
2.0%
0.2%
0.8%
2.4%
63.6%
DLL_queue logic
SPI
DW8051 mem
Baseband
Commercial Vertex Board
DLL_queue mem
UART
supervisor
Locationing
DW8051 logic
DLL
Clock cycles
Software execution time by task
35000
30000
25000
20000
15000
10000
5000
0
Total: 150 kGates (not including memory)
FITS EASILY ON SINGLE VERTEX
Total estimated area: 3.5 mm2
Check Tables
Forwarding
With Hardware
Accel
pkt Interest pkt
BWRC 2003 Winter Data
Retreat
Send to app
Power Domains─
State-Preserving Power-Down
Switched-Capacitor Converter
M6
loss
forpower
Standby
*
Supply Voltage
Generation
CL
K
NMOS
0.75V/-0.25V
PMOS 0.25V/-0.5V
CL
K
1V => 200mV
1.3uA => 6.5uA
Output Power = 1.3uw
M
9M
*
CL
K
CL
K
8
M
7
CL
K
CL
K
CL
K
•
Vout = 190mv +/- 3mv
CL
K
Efficiency:
90% w/o clock power
80% w/ clock power
CL
K
CL
K_
1.3 mm2 SRAM Leakage Control Test Chip
BWRC 2003 Winter Retreat
(0.13um Process, with 4K bytes SRAM embedded )
Power Domains
State-Preserving Power-Down
Ramped Supply
Some interesting observations:
• measured retention voltage: 250 mV (100 mV
simulated)
• leakage power reduction larger than anticipated:
5.4 mW at 0.3 V versus 241 mW at 1V (factor 45)
1V
Standard
Vdd
300mV
Standby Vdd
Memory Data Bit 4 @
Address 0xFFh
BWRC 2003 Winter Retreat
Factor 12
1V
Measured leakage current
Of 4 KB SRAM
Inter-board connectors
Verifying the Overall System―
Emulating a PicoRadio Network
FPGA
FPGA
Xbar
FPGA
96 bit inter-Xbar buses
•
BEE (Berkeley Emulation Engine)
– An Hierarchical Mesh-Connected Array of 20 Xilinx Vertex-2000 FPGA’s
– High-level Mapping Software Support – Simulink/Stateflow as the Preferred Input Format
– Extensive Debugging/Monitoring Support
•
•
Easily Supports 16+ PicoNodes and Evolved Channel Models
A New and Exciting Trend in System Verification
BWRC 2003 Winter Retreat
The Bottom Line: Total PicoNode Power
Pave = 250 mW
Dominated by TX
(+RX) power
Parameters:
• 3 packets/sec
• 200 bits/packet
• 20 bit pre-amble
• 5 neighbors
• Synchronization using
serendipitous rendezvous (or cycled
receiver) with Ton/T = 0.1
Dominated by
channel monitoring
power
Increasing data rate of radio reduces total power dissipation of
PicoNode! (based on real traffic models and implementation parameters)
BWRC 2003 Winter Retreat
The Impact of The Wake-Up Radio
Factor 5 to 10
reduction over
cycled receiver
BWRC 2003 Winter Retreat
Why an FPGA Implementation First?
Some Important Lessons Learned
• Sensor networks (even when statically deployed) are very
dynamic
– Susceptible to rapid changes in the channel. This is especially the case
when using simple radio’s (with limited diversity)
– In low-data rate applications, anything learned about the channel is
irrelevant when the next packet arrives (coherence time is less than 1 sec)
• Solutions:
– Make data-link layer reliable
– Use diversity (time, frequency, space) ─
Only spatial diversity offered by redundancy in sensor networks meets the
cost and energy requirements as well as the constraints offered by ad-hoc
networks.
Bottom Lines:
– Extensive statistics gathering at all the levels of the stack an
absolute necessity
– Given these observations, committing to a fixed protocol stack is
premature
BWRC 2003 Winter Retreat
Lessons Learned: Extensive Statistics
Gathering a Necessity
User Interface
Programs
Environment
Statistics and Management Service
Application Layer
Sensor Board I
HW
Temp.
Sensor
Sensor Board II
HW
Light
Sensor
HW
HW
Humidity
Sensor
HW
Accelerometer
SW
HW
Magnetometer
Monitor
Application Packet Drivers
SW
SW
parameter configuration
Manager
SMS Packet Drivers
SW
Network Layer
SW
Energy-Aware
Routing
Algorithm
SW
Neighbor List
Service
Queuing Service
SW
SW
Location
Service
Recorder
SW
Counter Control Service
SW
Datalink Layer
HW
Transmit
Controller
& Datapath
HW
Media Access
Controller
HW
Receive
Controller
& Datapath
Physical Layer
Bluetooth Radio
BWRC 2003 Winter Retreat
HW
CRC
Counters
HW
Session
Counters
Added “statistics and
management server” to
PicoNodeI Protocol stack
Measurements: Link Reliability
(narrow band Bluetooth channel)
BER: Flipped Bits: 20 Byte Packet
1400
79%
1200
Lesson Learned:
1000
• With 2 bits of ECC, we can recover
approximately 18% more data packets.
• Or …
800
# Packets
600
400
13%
5%
200
2%
1%
3
4
0%
0
0
% total returned
packets
1
2
# Flipped bits in a packet
BWRC 2003 Winter Retreat
5
Extend correlator from 4 to 10 taps
100.0
100.0
90.0
90.0
80.0
80.0
70.0
70.0
60.0
60.0
50.0
50.0
40.0
40.0
30.0
30.0
4 tap
BWRC 2003 Winter Retreat
0.0
5 RTS
10 tap
7 DTX
7 RTS
6 DTX
5 DTX
7 DTX
7 RTS
6 DTX
5 DTX
4 DTX
3 DTX
2 DTX
1 DTX
5 RTS
10.0
4 DTX
0.0
1 RTS
3 RTS
3 DTX
10.0
20.0
2 DTX
1 RTS
3 RTS
1 DTX
20.0
The Variability of Link Quality
Broadcast quality over time as measured at the
BWRC round-table on a Friday
Broadcast quality over time
60
Broadcast Success Rate [%]
50
40
30
20
10
0
10/19 h
12/43 h
11/31 h
13/55 h
15/07 h
16/19 h
Time
PicoRadio Meeting
BWRC 2003 Winter Retreat
NAMP Meeting
17/31 h
The Impact of Spatial Diversity
100.00
3 nodes
90.00
Broadcast success rate [%]
80.00
70.00
60.00
50.00
2 nodes
40.00
30.00
Deep
fade due to
multipath
20.00
10.00
0.00
0
10
20
30
40
50
60
70
80
Data gathered using
PicoNodeI testbed
90
100
110
120
130
140
150
160
170
180
190
200
distance [cm]
Adding a single node already changes broadcast reliability
dramatically – spacial diversity is the preferred way to
provide robustness in sensor networks
BWRC 2003 Winter Retreat
210
Making The Data Link More Reliable
MPMsg == UpdateLinkMetric/
UpdateNbList(UpdateLinkMetric)
Conditional
Add
Timeout == TRUE &&
LinkMetric >= ThresholdAdd/
SendLinkTestReq()
UpdateNbList(LinkTest)
MPMsg == CondAdd/
UpdateNbList(CondAdd)
Timeout == TRUE &&
LinkMetric < ThresholdAdd/
UpdateNbList(Clear)
Link Test
MPMsg == Success &&
Timeout == FALSE/
UpdateNbList(Active)
Timeout == TRUE /
UpdateNbList(Inactive)
Startup == TRUE
Inactive
Timeout == TRUE &&
LinkMetric < ThresholdRmv/
SendLinkTestReq()
UpdateNbList(LinkTest)
Active
Timeout == TRUE &&
LinkMetric >= ThresholdRmv/
UpdateNbList(Active)
Revised link layer keeps track of reliability of
channel
BWRC 2003 Winter Retreat
• Use only links that
prove to be reliable
over the long term
• Use RTS/CTS scheme
before transmission to
perform instantaneous
“channel estimation”
Energy Scavenging - Solar
Wires to load
Regulator and battery
Battery charging from solar cells
2.5
3 cm
volts
2
1.5
1
0.5
Lamp 12 inches from cells
Load disconnected
0
0
50
100
minutes
BWRC 2003 Winter Retreat
150
200
Energy Scavenging - Vibration
Super
Capacitor
Simulated Load
Power circuit
Piezo
Generator
Vibrometer
1 mA load
BWRC 2003 Winter Retreat
100 mA load
Energy Scavenging - Vibration
Piezo-bender
prototyped for
“in-tire” sensor network
BWRC 2003 Winter Retreat
Status/Summary
PicoNodes becoming a reality!
PicoNode IIIv1
• First integrated sub-mW node, combining custom
components with some of the shelf elements – Average
Power dissipation estimated around 400 mW
• Operation of FBAR radio demonstrated; Integration
version (2 channel) in fab
• Full functionality of protocol processor demonstrated on
FPGA – system level verification under progress;
processor chip in fab in March
• Concepts of power-domains and voltage-down retention
demonstrated
• Energy scavenging sub-system implemented and
functionality demonstrated
BWRC 2003 Winter Retreat
Perspectives: Beyond PN III
• Extending the Lifetime of Sensor
Networks
• Wake-up Radio
• Localization
• Design Methodology (with GSRC)
– “Ambient Intelligence one of main GSRC drivers”
• Bringing Power even Lower!
– Reliable computation on unreliable platforms
Computation in the ultra low-voltage space
• Exploring New Application Spaces
BWRC 2003 Winter Retreat
Lifetime of Sensor Networks
The hot-spot problem
D. Petrovic, R. Shah, K. Ramchandran
Project funded by NSF
BWRC 2003 Winter Retreat
How to mitigate hot-spots in
sensor networks?
• Intelligent routing
• Data aggregation
• Distributed coding
• Topology planning
• Altruistic nodes
• Dynamic relocation of
functionality
Established strict upper-bounds
on lifetime!
Combining Aggregation and Coding
Coding by Ordering
Store information in data order
Unique
ID  {1,2,3,4} Payload {1,..., 6}
1
2
3
4
Controller
Sensors
Border
Node
Packet aggregation suppresses
header overhead
BWRC 2003 Winter Retreat
2
4
0
2
2
1
3
Ordering corresponds to
integer 2 = payload of packet 4
Computation in the Ultra-Low Voltage Space
• Power dissipation becoming the
main roadblock towards further
integration!
• Aggressive voltage scaling seems to
be the only plausible answer
• Offers the opportunity for reducing
power dissipation of mobile sensor
nodes by other major fraction
BWRC 2003 Winter Retreat
4.5
4
Supply Voltage (V)
– Intel Processor Integration is “power
constrained”
– Drain-source leakage a major fraction
of power dissipation – direct function of
supply voltage
– Gate leakage one of the main emerging
challenges – again, a very strong
function of supply voltage
5
3.5
3
2.5
2
1.5
1
0.5
1
-1
10
Minimum Feature Size (micron)
SIA Roadmap not
aggressive enough?
Computation in the Ultra-Low Voltage Space
How low can we go?
• Gain limitations but lower bound on supply voltage on a
couple of kT/q
• While many noise sources scale, some do not!
– Thermal noise
– Soft errors
Circuits are bound to start producing errors when supply voltages are
aggressively scaled!
• Variability of threshold voltage remains approximately
constant, causing gate performance to vary widely
 Explore circuit and architecture techniques that deal with
performance variations (e.g., self-timed) and are
(somewhat) resilient to errors!
BWRC 2003 Winter Retreat
Some First-Order Results
• Studied distribution of
delay over wide range
of process parameters
(simple inverter chain)
using Monte Carlo
Analysis
• PDF shows lognormal
distribution – this is,
Gaussian is not a
good model
BWRC 2003 Winter Retreat
Some Intriguing New Applications
Everyday Computing
Addressing the “everyday
problem”
(e.g. Where are my keys?)
Courtesy of Mik Lamming and Jim Rowson,
HP Labs
BWRC 2003 Winter Retreat
ISSCC 2002 Jack Raper Award for
Outstanding Technology Directions Paper
“PicoRadios for Wireless Sensor
Networks: The Next Challenge in
Ultra-Low Power Design”
J. M. Rabaey, J. Ammer, T. Karalar,
S. Li, B. Otis, M. Sheets, T. Tuan
BWRC 2003 Winter Retreat