Transcript Spartan erv 8415new vehicle information

SPARTAN ERV 8415
NEW VEHICLE INFORMATION
Spartan ERV 8415
• Diesel Exhaust Fluid – Location, maintenance,
indicator faults
• Exhaust Regeneration – What it is and how to
read indicator lights
• Manual pump engagement procedure
DEF
Diesel Exhaust Fluid
Location
• The DEF tank is
located inside the
rear of the cab.
The access door
can be found
behind the Drivers
seat in the step
well.
Refilling
• The DEF tank will hold 5
gallons of Diesel Exhaust
Fluid. The message
center located on the
dash has a green fluid
level indicator above the
fuel gauge. If the tank
falls below 15% an
audible reminder and
message will appear,
reminding you to refill
the tank.
Diesel Particulate Regeneration
• 8415 is equipped with an after treatment
diesel particulate filter. This type of exhaust
system uses high heat and DEF to clean the
exhaust before it leaves the tailpipe.
• The following indicator lights may appear
during operation to make the driver aware of
the regeneration process
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Safety Warning:
The Diesel Particulate Filter has been designed by the
OEM to perform the regeneration process while the
vehicle is in motion. While the vehicle is performing
regeneration exhaust gas temperatures can reach 1500
degrees. Although this should occur while the vehicle is
in motion, care should be taken to avoid parking the
apparatus within 5’ of items that can burn, melt, or
explode.
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Diesel Particulate Regeneration
Manual Pump
Engagement
Manual Pump Engagement
• Bring the vehicle to
a stop. Place the
transmission in
Neutral and apply
the parking brake.
Manual Pump Engagement
• Move the road to
pump switch to
Neutral.
Manual Pump Engagement
• Exit the cab and
pull the manual Thandle located
bottom right on
the panel. Apply
firm pressure to
move the handle.
When applied the
handle will move
approx 2 “.
Manual Pump Engagement
• If the handle will
not move, place
the transmission in
R then D back to N.
Repeat attempt to
engage T-handle.
Manual Pump Engagement
• Return to the cab
and activate the
emergency pump
switch. The red
indicator light will
come on. Place
the transmission in
Drive.
Manual Pump Engagement
• Reverse the
engagement
procedure to drive
the vehicle.